NTSB Animation – Overview of the collapse of the Fern Hollow Bridge

On Friday, January 28, 2022, about 6:37 a.m. eastern standard time, the Fern Hollow Bridge, which carried Forbes Avenue over the north side of Frick Park in Pittsburgh, Allegheny County, Pennsylvania, experienced a structural failure. As a result, the 447-foot-long bridge fell about 100 feet into the park below. The collapse began when the transverse tie plate on the southwest bridge leg failed due to extensive corrosion and section loss. The corrosion and section loss resulted from clogged drains that caused water to run down bridge legs and accumulate along with debris at the bottom of the legs, which prevented the development of a protective rust layer or patina. Although repeated maintenance and repair recommendations were documented in many inspection reports, the City of Pittsburgh failed to act on them, leading to the deterioration of the fracture-critical transverse tie plate and the structural failure of the bridge. At the time of the collapse, a 2013 New Flyer articulated transit bus, operated by the Port Authority of Allegheny County, and four passenger vehicles were on the bridge. A fifth passenger vehicle drove off the east bridge abutment after the collapse began and came to rest on its roof on the ground below. As a result of the collapse, the bus driver sustained minor injuries and two bus occupants were uninjured. Of the six passenger vehicle occupants, two sustained serious injuries, one sustained a minor injury, two were uninjured, and the injury status of one was unknown.